《TSS规格书.pdf》由会员分享，可在线阅读，更多相关《TSS规格书.pdf（8页珍藏版）》请在taowenge.com淘文阁网|工程机械CAD图纸|机械工程制图|CAD装配图下载|SolidWorks_CaTia_CAD_UG_PROE_设计图分享下载上搜索。
1、All data is subject to change,Please check our data sheets at www ruilon com for updates.2012 RuiLong Yuan,Inc.P0060P3500LA_B_C SeriseThyristor Surge SuppressorsTSS 01The P0060P3500LA_B_C Series are designed to protect baseband equipment such as modems,line cards,CPE and DSL from damaging overvoltag
2、e transients.The series provides a cost-effective through-hole solution that enables equipment to comply with global regulatory standards.DescriptionFeatures and Benefits Low voltagr overeshoot Low on-state voltage Does not degrade with use Fails short circuit when surged in excess of ratings Low Ca
3、pacitanceApplicable Global Standards TIA-968-A ITU K.20/21 Enhanced level*ITU K.20/21 Basic Level GR 1089 Inter building*GR 1089 Inter building IEC 6100-4-5 YD/T 1082 YD/T 993 YD/T 950P0080LBLogoVdrm0:Represents a chipPeak pilse current-Ipp 8/20sA=150AB=250AC=400ATypeS:SMD SMBT:SMD SMAE:DIP TO-92L:D
4、IP D0-15Product NameAll data is subject to change,Please check our data sheets at www ruilon com for updates.2012 RuiLong Yuan,Inc.Electriacl Characteristics(TA=25 C Unless Otherwise Noted)TSS 02DO-204AC/DO-15Type NumberVDRMIDRMVBOIHISITVTCJPackage Dimensionsinch(mm)VAVMAMAAVpFMinpFMaxP0080LA6525508
5、002.2425150P0080LB6525508002.2425150P0080LC6525508002.2435260P0300LA25540508002.2415140P0300LB25540508002.2415140P0300LC25540508002.2425250P0640LA585771508002.244060P0640LB585771508002.244060P0640LC585771508002.2455155P0720LA655881508002.243560P0720LB655881508002.243575P0720LC655881508002.2450150P09
6、00LA755981508002.243555P0900LB755981508002.243570P0900LC755981508002.2445140P1100LA9051301508002.243050P1100LB9051301508002.243070P1100LC9051301508002.2445115P1300LA12051601508002.242545P1300LB12051601508002.242560P1300LC12051601508002.2440105P1500LA14051801508002.242540P1500LB14051801508002.242555P
7、1500LC14051801508002.243595P1800LA17052201508002.242535P1800LB17052201508002.242550P1800LC17052201508002.243590P2300LA19052601508002.242535P2300LB19052601508002.242550P2300LC19052601508002.243080P2600LA22053001508002.242035P2600LB22053001508002.242045P2600LC22053001508002.243080P3100LA27553501508002
8、.242035P3100LB27553501508002.242045P3100LC27553501508002.243070P3500LA32054001508002.242035P3500LB32054001508002.242040P3500LC32054001508002.242565Notes:-Absolute maximum ratings measured at TA=25C(unless otherwise noted).-Devices are bi-directional.SERIESPeak Pilse Current-lpp(A)2/10s8/20s10/160s10
9、/560s10/1000sA2001501006050B25025015010080C500400200120100All data is subject to change,Please check our data sheets at www ruilon com for updates.2012 RuiLong Yuan,Inc.TSS 03Surge RatingsSeriesIPPITSM50/60 Hzdi/dt0.2x310 10.5x700 22x10 12x10 28x20 11.2x50 210 x160 110 x160 210 x560 110 x560 25x320
10、19x720 210 x360 110 x360 210 x1000 110 x1000 25x310 110 x700 2A minA minA minA min A minA minA minA minA minA minA/s maxA2015015090507575457520500B252502501501001001258010025500C5050040020015020017510020030500Notes:1 Current waveform in s2 Voltage waveform in s-Peak pulse current rating(IPP)is repet
11、itive and guaranteed for the life of the product.-IPP ratings applicable over temperature range of-40C to+85C-The device must initially be in thermal equilibrium with-40C TJ +150CIHITISIDRMVDRMVT+V-V+I-IVSIHITISIDRMVDRMVT+V-V+I-IVSV-I Characteristics501000trtd0PeakValueHalf Valuet Time(s)IPP Peak Pu
12、lse Current%IPPtr=rise time to peak valuetd=decay time to half valueWaveform=trx tdtr x td Pulse Wave-form-8-40-20020406080 100 120 140 160-6-402468101214Junction Temperature(TJPercent of VSChange%Normalized VS Change versus Junction Temperature0.4-40-2002040 6080 100 120 140 1600.60.81.01.21.41.61.
13、82.0Case Temperature(TCRatio ofIHIH(TCNormalized DC Holding Current versus Case TemperatureAll data is subject to change,Please check our data sheets at www ruilon com for updates.2012 RuiLong Yuan,Inc.TSS 04t inUeul aVretemaraPlobmySegakcaPDO-15TJOperating Junction Temperature RangeCTSStorage T emp
14、erature RangeCR0JAThermal Resistance:Junction to Ambient60C/WThermal ConsiderationsTimeerutarepmeTTPTLTS(max)TS(min)25tPtLtStime to peak temperature(t 25C to peak)Ramp-downRamp-upPreheatCritical ZoneTL to TPFigure 1Soldering ParametersPb-Free assembly(see Fig.1)Pre Heat-Temperature Min(Ts(min)-Tempe
15、rature Max(Ts(max)-Time(Min to Max)(ts)60-180 secs.Average ramp up rate(Liquidus Temp(TL)to peak)3C/sec.Max.TS(max)to TL-Ramp-up Rate3C/sec.Max.-Temperature(TL)(Liquidus)-Temperature(tL)60-150 secs.Peak T emp(TP)Time within 5C of actual Peak T emp(tp)30 secs.Max.Ramp-down Rate6C/sec.Max.Time 25C to
16、Peak Temp(T)8 min.Max.t inUeul aVretemaraPlobmySegakcaPDO-15TJOperating Junction Temperature RangeCTSStorage T emperature RangeCR0JAThermal Resistance:Junction to Ambient60C/WThermal ConsiderationsTimeerutarepmeTTPTLTS(max)TS(min)25tPtLtStime to peak temperature(t 25C to peak)Ramp-downRamp-upPreheat
17、Critical ZoneTL to TPFigure 1Soldering ParametersPb-Free assembly(see Fig.1)Pre Heat-Temperature Min(Ts(min)-Temperature Max(Ts(max)-Time(Min to Max)(ts)60-180 secs.Average ramp up rate(Liquidus Temp(TL)to peak)3C/sec.Max.TS(max)to TL-Ramp-up Rate3C/sec.Max.-Temperature(TL)(Liquidus)-Temperature(tL)
18、60-150 secs.Peak T emp(TP)Time within 5C of actual Peak T emp(tp)30 secs.Max.Ramp-down Rate6C/sec.Max.Time 25C to Peak Temp(T)8 min.Max.All data is subject to change,Please check our data sheets at www ruilon com for updates.2012 RuiLong Yuan,Inc.TSS 05 Figure 1.Examples of protection stages for lin
19、e cardsIn such a stage,parallel function is assumed by one or several Trisil,and is used to protect against short duration surge(lightning).During this kind of surges the Trisil limits the voltage across the device to be protected at its break over value and then fires.The fuse assumes the series fu
20、nction,and is used to protect the module against long duration or very high current mains disturbances(50/60Hz).It acts by safe circuit opening.Lightning surge and mains disturbance surges are defined by standards like GR1089,FCC part 68,ITU-T K20.Figure 2.Typical circuitsLineegat s no i t cetorPega
21、t s no i t cetorPRingrelayLinel animret ro drac eni l LSDx.xEdrac eni l gol anA.xEFuseTCP 1.25AT1T2Typical circuit for subscriber sideFuseTCP 1.25ATip SGndRing SFuseTCP 1.25ATip LGndRing LTypical circuit for central office sideFigure 3.Test circuit 1 for Dynamic IBO and VBO parameters100V/s,di/dt 10
22、 A/s,Ipp=XXXA1k V/s,di/dt 10 A/s,Ipp=10 AUU10 F24566470830.36 nF46 H60 F26 H1225046 H47KeyTek System 2 generatorw ithP N246I moduleKeyTek System 2 generatorw ithP N246I moduleAll data is subject to change,Please check our data sheets at www ruilon com for updates.2012 RuiLong Yuan,Inc.Figure 4.Test
23、circuit 2 for IBO and VBO parameters220V 50Hz1/4R1=140R2=240Kton=20msIBOmeasurementVBOmeasurementVoutDUTTEST PROCEDUREPulse test duration(tp=20ms):Vselection:for Bidirectional devices=Switch K is closedfor Unidirectional devices=Switch K is openDevice with V 200VV=250V,R1=140OUTBOOUTRMSDevice with V
24、200VV=480V,R2=240BOOUTRMSFigure 5.Test circuit 3 for dynamic IH parameterTEST PROCEDURE1/Adjust the current level at the Ivalue by short circuiting the AK of the D.U.T.2/Fire the D.U.T.w ith a surge currentHI=10A,10/1000s.3/The D.U.T.w ill come back off-state within 50ms maximum.PPThis is a GO-NOGO
25、test which allows to confirm the holding current(I)level in afunctional test circuit.HRVBAT=-48 VSurge generatorD.U.TTSS 06All data is subject to change,Please check our data sheets at www ruilon com for updates.2012 RuiLong Yuan,Inc.TSS 07Lead MaterialCopper AlloyTerminal Finish100%Matte-Tin Plated
26、Body MaterialHigh Temp Voltage Blocking80%Rated VDRM(VAC Peak 504 or 1008 hrs.MIL-STD-750(Method 1040)JEDEC,JESD22-A-101Temp Cyclingcycles.MIL-STD-750(Method 1051)EIA/JEDEC,JESD22-A104Biased Temp&Humidity52 VDCJEDEC,JESD22-A-101High Temp StorageJEDEC,JESD22-A-101Low Temp Storage-65C,1008 hrs.Thermal
27、 Shock10 cycles.MIL-STD-750(Method 1056)JEDEC,JESD22-A-106Autoclave(Pressure Cooker Test)JEDEC,JESD22-A-102Resistance to Solder HeatMoisture Sensitivity LevelPart MarkingPart NumberingCONSTRUCTION VARIABLEREEL PACKIPP RATINGRoHS COMPLIANTTYPEP=SIDACtorP x L RPMEDIAN VOLTAGE PACKAGE TYPExxx 0 GPxxxxP
28、art Marking Code(Refer to Electrical Characteristics Table)Dimensions DO-15LLGDBDimensionInchesMillimetersMINMAXMINMAXB0.0280.0340.7110.864D0.120.143.0483.556G0.2350.275.9696.858L4.521Packing OptionsPackage TypeDescriptionQuantityAdded Industry StandardGDO-15 Axial Tape&Reel2000RPEIA-RS-296-DSpacing
29、 off center,either side0.039(1.0)BCADErecess depth max 0.7 5”2.55(64.8)TYP3.15(80.0)TYP Dimensionsare in inches(and millimeters).Direction of FeedGSymbolsDescriptionInchesMMAComponent Spacing(lead to lead)5.08 0.508BInner Tape Pitch52.37 1.498CTape Width6.35DMax.Off Alignment1.219EReel Dimension330.
30、2FMax.Hub Recess76.19GMax.Abor Hole17.27Lead MaterialCopper AlloyTerminal Finish100%Matte-Tin PlatedBody MaterialHigh Temp Voltage Blocking80%Rated VDRM(VAC Peak 504 or 1008 hrs.MIL-STD-750(Method 1040)JEDEC,JESD22-A-101Temp Cyclingcycles.MIL-STD-750(Method 1051)EIA/JEDEC,JESD22-A104Biased Temp&Humi
31、dity52 VDCJEDEC,JESD22-A-101High Temp StorageJEDEC,JESD22-A-101Low Temp Storage-65C,1008 hrs.Thermal Shock10 cycles.MIL-STD-750(Method 1056)JEDEC,JESD22-A-106Autoclave(Pressure Cooker Test)JEDEC,JESD22-A-102Resistance to Solder HeatMoisture Sensitivity LevelPart MarkingPart NumberingCONSTRUCTION VAR
32、IABLEREEL PACKIPP RATINGRoHS COMPLIANTTYPEP=SIDACtorP x L RPMEDIAN VOLTAGE PACKAGE TYPExxx 0 GPxxxxPart Marking Code(Refer to Electrical Characteristics Table)Dimensions DO-15LLGDBDimensionInchesMillimetersMINMAXMINMAXB0.0280.0340.7110.864D0.120.143.0483.556G0.2350.275.9696.858L4.521Packing OptionsP
33、ackage TypeDescriptionQuantityAdded Industry StandardGDO-15 Axial Tape&Reel2000RPEIA-RS-296-DAll data is subject to change,Please check our data sheets at www ruilon com for updates.2012 RuiLong Yuan,Inc.RUILONG.YUAN CO.,LTDTel:+86-0755-82908296 Fax:+86-0755-82908002RuiLongYuan Electronics are trade
34、marks.Information furnished is believed to be accurate and reliable.However,users should independently evaluate the suitability of and test each product selected for their own applications.RUILONYUAN Electronics reserves the right to change or update,without notice,any information contained in this
35、publication;to change,without notice,the design,construction,processing,or specification of any product;and to discontinue or limit production or distribution of any product.This publication supersedes and replaces all information previously supplied.Without expressed or written consent by an office
36、r of RUILONYUAN Electronics,RUILONYUAN Electronics does not authorize the use of any of its products as components in nuclear facility applications,aerospace,or in critical life support devices or systems.RUILONYUAN Electronics expressly disclaims all implied warranties regarding the information con
37、tained herein,including,but not limited to,any implied warranties of merchantability or fitness for a particular purpose.RUILONYUAN Electronics only obligations are those in the RUILONYUAN Electronics Standard Terms and Conditions of Sale and in no case will RUILONYUAN Electronics be liable for any incidental,indirect,or consequential damages.Email:Website:http:/TSS 08