《井筒 电气焊拆除安全措施.doc》由会员分享，可在线阅读，更多相关《井筒 电气焊拆除安全措施.doc（57页珍藏版）》请在taowenge.com淘文阁网|工程机械CAD图纸|机械工程制图|CAD装配图下载|SolidWorks_CaTia_CAD_UG_PROE_设计图分享下载上搜索。
1、【精品文档】如有侵权，请联系网站删除，仅供学习与交流井筒 电气焊拆除安全措施.精品文档.义煤集团洛阳神和煤业有限公司副井井筒50管电气焊拆除安全措施编号： YMCSTFSHK201303措施批准时间： 年 月 日措施执行时间： 年 月 日会审单位及人员签字施工单位： 安全副总：编制人员： 通风副总：队 长： 地测副总：生 产 科： 生产副总：通 风 科： 机电矿长：机 电 科： 安全矿长：安 监 科： 生产矿长：地 测 科： 总工程师：副井井筒50管电气焊拆除安全措施一、 作业内容副井井筒因工作需要需敷设两根MYJV42 8.7/10KV 350/10KV动力电缆，在施工过程中需使用电气焊拆除
2、副井水仓以下60米的50管路并使用绞车将拆除后的管路运至地面，为保证施工安全，特编制本电气焊使用安全技术措施。二、 施工地点 副井井筒三、 施工时间2013年 7月 28日四、 施工组织技术负责人：司青振施工负责人：薛向和安全负责人：薛明星电气焊工：每班安排的电气焊（割）工（签字后作业）五、 施工前准备1、编写施工安全技术措施，审批后，组织施工人员认真学习措施并签字。2、施工前准备好电焊机、电焊条、氧气、乙炔、电气焊用具、绝缘手套及常用工具。3、清理施工现场，各施工材料准备齐确保不存在安全隐患。电气焊工必须持证上岗。六、 安全技术措施1、每次电气焊施工前必须组织所有参加人员认真学习本措施并签名
3、，签字后方可参加施工。认真落实施工及安全注意事项，严格按措施施工2、工作地点要有专职安全员进行检查和监督，配备两台灭火器、两只消防水桶和一把消防铁锹，施工前要在施工地点接有水管并对工作地点进行洒水，充分湿润，割下的铁块或电焊条头及时用水熄灭或放置在盛有水的消防桶内。3、瓦检员在施工前对施工地点瓦斯浓度进行检查，同时在施工过程中密切监视检查变化情况，一旦发现浓度达到0.8%，应立即停止电气焊作业，加强通风进行处理，达到规程要求后，方可恢复施工。4、电焊、气割周围10米范围内不得有可燃性材料。施工负责人要提前检查施工现场，彻底清理施工范围内的杂物及浮煤等易燃物品。5、工作地点要求有良好的通风，以及
4、时排除工作场所有害气体。6、施工负责人要提前对使用的工具、电气焊用具材料等全面检查，严禁使用不合格的电气焊用具。7、施工前，必须在施工现场周围设警戒线，拉警戒绳，并有专人监管。8、电气焊用具操作前检查内容：（1）、乙炔发生器（乙炔瓶）、氧气瓶、胶管接头、阀门的紧固件应紧固牢靠，不准松动，破烂和漏气。护圈、气嘴、保护帽必须保证完好，气瓶要有防震胶圈，带有安全帽。（2）、氧气瓶、乙炔管有漏气、老化、龟裂等，不得使用。管内应保持清洁，不得有杂物。（3）、检查防护面具是否完好，镜片和电焊手套是否完好。9、氧气、乙炔瓶在撞车及运输过程中必须要专人搬运，专人看护，要分装分运，轻拿轻放；使用时必须采用防滑装
5、置，用其他物件把钢瓶固定牢固，防止钢瓶下滑或歪倒伤人。10、旋开氧气瓶、乙炔瓶阀门时不要太快，防止压力气流激增，造成瓶阀冲出等事故，减压器与瓶阀连接必须可靠，严禁漏气，避免发生爆炸事故。11、氧气瓶、乙炔瓶应放置牢固，乙炔瓶必须垂直放置，不得卧放，以防丙酮流出。乙炔瓶不能遭受剧烈的震动和撞击，以免瓶内的对空性填料下沉形成空洞，影响乙炔的存储。12、气带、割具连接后，必须妥善保管，防止受到碾压和其他外力冲击，焊具停止使用时必须放置在安全位置，不准随意乱放。13、电焊机、把子线、地线、电焊把子在使用前必须检查是否完好，严禁使用不合格的电焊用具。电焊机必须由专职电工进行接线，接线时必须停电，严格按电
6、焊机说明书接线，并执行好停电、验电、放电三保险制度。14、电焊工应熟悉现场的工作，电焊技术熟练，工作时应戴好防护用品，并持证上岗，其他人员严禁操作施工，电焊把子严禁对准人和其他用品，不要把电焊钳夹在腋下活将电缆绕挂在脖子上搬移被焊物件。改变焊机接头，检修焊机或转移工作地点时，必须停电，严格执行停送电制度，15、气割时，要保护好气带，防止镏渣烧坏气带。气焊工必须佩戴好防护用品。施工中发生回火时应先关氧气阀后关乙炔阀，乙炔管着火时，可采用弯折管的方法熄火。16、在使用气割时，氧气瓶，乙炔瓶必须在施工地点上风侧，氧气瓶、乙炔瓶依次放在施工地点10米以外，且两瓶相距5米以上。17、氧气瓶、乙炔瓶及气带
7、上严禁有油迹。不准用带油渍的手套搬运、操作电焊用具。18、安全负责人要认真负责，及时检查工作现场的不安因素，发现问题及时处理，并监督好措施执行情况。19、施工现场必须由一名区队干部盯班，同时安全负责人要认真履行职责，确保施工安全。20、在电气焊时，若附近有电缆线路，必须先将电缆线保护好后方能进行电气焊作业，且作业后及时用水将热点区域浇至常温。21、烧焊过程中，要确保施工质量，发现问题及时整改。22、施工过程中，所有人员要听从施工负责人的统一指挥，任何人不得违章作业，违章指挥。中断或结束后，要安排专人清理现场，消灭残余火23、烧焊种。一小时后无问题，方可离开现场。25、电气焊施工完毕后，工作地点
8、应该再次在施工地点10米范围内用水喷洒，并安排专人在工作地点留守检查一小时，发生异常情况立即处理，知道确认无问题后方可离开现场。26、其他未尽事宜严格按煤矿安全规程和工种操作规程中的有关规定执行。 神和煤业有限公司机电科 2013年7月28日副井井筒50管电气焊拆除安全措施作业规程措施贯彻记录主持人: 贯彻人: 贯彻地点: 贯彻时间: 年 月 日 班次： 参加人员参加人员序号姓名工种签字成绩序号姓名工种签字成绩119220321422523624725826927102811缺席人员12序号姓名工种131142153164175186应到人数： 人 实到人数： 人 缺席人数： 人 (表格字体为
9、五号宋体)（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supe
10、rvision of major initiatives. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list,
11、 focusing on vertical gauge, draw the party organizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the in
12、terpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the par
13、ty. and revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a
14、Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the ma
15、sses of the people reflect a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, r
16、eflects the partys eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party
17、to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohib
18、ited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems,
19、 and is narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been una
20、ble to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party
21、constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulatio
22、ns first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of
23、 the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the centra
24、l deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations re
25、vision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department
26、The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a no
27、tice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central
28、 Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two
29、 regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision
30、 work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite
31、in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasse
32、s party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipl
33、ine Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of v
34、irtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordanc
35、e with the regulations governing the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few
36、, emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a posit
37、ive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in th
38、e party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the cen
39、tral eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to
40、grasp several key problems (a) adhere to according to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements an
41、d specifications, showing Communists noble moral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the provisions of . the second is adhere to a positive advocate,
42、 eight prohibition 52 are not allowed to about the content of the negative list moved into synchronization amendment . Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly r
43、equired. The fourth is prominent key minority, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised is the ruling Par
44、ty since the first insists on a positive advocate forAll Party members and the self-discipline norms, moral declaration issued to all members of the party and the National Peoples solemn commitment. criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After t
45、he revision of the , a total of eight, 281 words, including lead, specification and Party member cadre clean fingered self-discipline norms, etc. Part 3 members low-cost clean and self-discipline, the main contents can be summarized as four must eight code. Lead part, reiterated on ideal and faith, fundamental purpose, the fine traditions and work style, noble sentiments